Testing method and distribution characteristics of spatial pesticide spraying deposition quality balance for unmanned aerial vehicle

Changling Wang, Xiongkui He, Xiaonan Wang, Zhichong Wang, Shilin Wang, Longlong Li, Jane Bonds, Andreas Herbst, Zhiguo Wang

Abstract


In order to explore the spatial pesticide spraying deposition distribution, the downwash flow field characteristics for unmanned aerial vehicle (UAV) pesticide application with accurate flight height and velocity and the relationship of these two aspects, a novel measurement method was proposed in this paper. A model ‘3WQF80-10’ single-rotor diesel UAV was tested using this method in wheat field and the effects of flight direction, flight parameters and crosswind on the distribution of spatial spraying deposition quality balance (SSDQB) and the downwash flow field distribution were researched. A cuboid aluminum sampling frame of spatial spraying deposition quality balance (SFSSDQB) with monofilament wires was made for collecting the droplets in four directions, and a set of multi-channel micro-meteorology measurement system (MMMS) was applied for measuring the downwash wind speed in three directions. Besides, BeiDou Navigation Satellite System (BNSS) was used for controlling and recording the working height, velocity and track of this model of single-rotor UAV. The results showed the distribution of the spatial spray deposition and the downwash flow field of UAV could be measured effectively at exact flight height and velocity via this method. When the average wind speed was 0.9 m/s, the average temperature was 31.5°C and the average relative humidity was 34.1%, and the average distribution ratios of spraying deposition for model ‘3WQF80-10’ UAV on the upwind part, the top part, the downwind part and the bottom part were 4.4%, 2.3%, 50.4% and 43.7%, respectively. The flight directions of forward and backward had an impact on droplet deposition distribution and the working effect of flying backwards, with 60% of deposition ratio of the bottom part of the SFSSDQB, was better than flying forward. There was a linear negative correlation between the coefficient of variation (CV) of the bottom part and the flight height and the coefficient of determination was 0.9178, which means that the deposition distribution becomes more uniform with the increase of height. Additionally, there was a linear positive correlation between weighted mean deposition rate and crosswind speed and the coefficient of determination was 0.9684, which shows the deposition distribution gets more concentrated towards the downwind part with the rise of crosswind speed. Therefore, according to the results of tests of downwash airflow speed, it is shown that regardless of the flight direction and height and the crosswind, all these factors influence the droplet deposition distribution via weakening the intensity of the downwash airflow field in the direction perpendicular to the ground. The results can provide valuable information for the research of UAV pesticide application techniques and the establishment of the standard of spraying deposition and drift tests of UAV in crop field.
Keywords: unmanned aerial vehicle (UAV), spatial spraying deposition, distribution, downwind airflow, flow field
DOI: 10.25165/j.ijabe.20181102.3187

Citation: Wang C L, He X K, Wang X N, Wang Z C, Wang S L, Li L L, et al. Testing method and distribution characteristics of spatial pesticide spraying deposition quality balance for unmanned aerial vehicle. Int J Agric & Biol Eng, 2018; 11(2): 18–26.

Keywords


unmanned aerial vehicle (UAV), spatial spraying deposition, distribution, downwind airflow, flow field

Full Text:

PDF

References


Fan Q N. The Research on the Pesticide Spray System Using for the Mini Unmanned Helicopter. Nanjing: Nanjing Forestry University, 2011. (in Chinese)

Shao Z R, Guo Y W. Situation and strategies of spraying facilities and pesticide application technology in China. Plant Protection, 2006; 32(2): 5–8. (in Chinese)

Zhou Z Y, Zang Y, Luo X W, et al. Technology innovation development strategy on agricultural aviation industry for plant protection in China. Transactions of the CSAE, 2013; 29(24): 1–10. (in Chinese)

He X K. Improving severe draggling actuality of plant protection machinery and its application techniques. Transactions of the CSAE, 2004; 20(1): 13–15. (in Chinese)

Ma X Y, Wang Z G, Jiang W L, et al. Analysis of current status and application prospects of unmanned Aerial Vehicle Plant protection technology in cotton field in China. China Cotton, 2016; 43(6): 7–11. (in

Chinese)

Bird S L, Esterly D M, Perry S G. Off-target deposition of pesticides from agricultural aerial spray applications. Journal of Environmental Quality, 1995; 25(5): 1095–1104.

Huang Y B, Hoffmann W C, Lan Y B, et al. Development of a spray system for an unmanned aerial vehicle platform. Transactions of the ASABE, 2009; 25(6): 803–809.

Huang Y B, Thomson S J. Characterization of spray deposition and drift from a low drift nozzle for aerial application at different application altitudes. Int J Agric & Biol Eng, 2011; 4(4): 28－33.

Bradley K F, Hoffmann W C, Bagley W E, Hewitt A. Field scale evaluation of spray drift reduction technologies from ground and aerial application systems. Journal of ASTM International, 2011; 8(5): 1–11.

Giles D K, Billing R. Unmanned aerial platforms for spraying: deployment and performance. Aspects Appl. Bio., 2014; 12: 63–69.

Giles D K. Use of Remotely Piloted Aircraft for Pesticide Applications: Issues and Outlook. Outlooks on Pest Management, 2016; 27(5): 213–216.

Giles D K, Billing R, Singh W. Performance results, economic viability and outlook for remotely piloted aircraft for agricultural spraying. Aspects of Applied Biology 132, International Advances in Pesticide Application, 2016; pp.15–21.

Wang C L, He X K, Liu Y J, et al. The small single- and multi-rotor unmanned aircraft vehicles chemical application techniques and control for rice fields in China. Aspects of Applied Biology 132, International Advances in Pesticide Application, 2016; pp.73–81.

He X K, Bonds J, Herbst A, et al. Recent development of unmanned aerial vehicle for plant protection in East Asia. Int J Agric & Biol Eng, 2017; 10(3): 18–30.

Fritz B K, Kirk I W, Hoffmann W C, et al. Aerial application methods for increasing spray deposition on wheat heads. Applied Engineering in Agriculture, 2006; 22(3): 357–364.

Zhang J, He X K, Song J L, et al. Influence of spraying parameters of unmanned aircraft on droplets deposition. Transactions of the Chinese Society for Agricultural Machinery, 2012; 43(12): 94–96. (in Chinese)

Bae Y, Koo Y M. Flight attitudes and spray patterns of a roll-balanced agricultural unmanned helicopter. Applied Engineering in Agriculture, 2013; 29(5): 675–682.

Qiu B J, Wang L W, Cai D L, et al. Effect of flight altitude and speed of unmanned helicopter on spray deposition uniform. Transactions of the CSAE, 2013; 29(24): 25–32. (in Chinese)

Qin W C, Qiu B J, Xue X Y, et al. Droplet deposition and control effect of insecticides sprayed with an unmanned aerial vehicle against plant hoppers Crop Protection, 2016; 85: 79–88.

Zhang P, Deng L, Lyu Q, et al. Effects of citrus tree-shape and spraying height of small unmanned aerial vehicle on droplet distribution. Int J Agric & Biol Eng, 2016; 9(4): 45–52.

Wang C L, Song J L, He X K, et al. Effect of flight parameters on distribution characteristics of pesticide spraying droplets deposition of plant-protection unmanned aerial vehicle. Transactions of the CSAE, 2017; 33(23): 109–116. (in Chinese)

ISO/TC 23/SC 6. ISO 24253-1:2015. Crop protection equipment－Spray deposition test for field crop.

Smith D B. Uniformity and recovery of broadcast spray using fan nozzles. Transactions of the ASAE, 1992; 35: 39–44.

Li J Y, Zhou Z Y, Hu L, et al. Optimization of operation parameters for supplementary pollination in hybrid rice breeding using uniaxial single-rotor electric unmanned helicopter. Transactions of the CSAE, 2014; 30(10): 10–17. (in Chinese)

Shi Q. Numerical simulation for downwash flow field of small-size unmanned helicopter hedgehopping. Journal of Drainage and Irrigation Machinery Engineering (JDIME), 2015; 33(6): 521–525. (in Chinese)

Liao J, Zang Y, Zhou Z Y, et al. Quality evaluation method and optimization of operating parameters in crop aerial spraying technology. Transactions of the CSAE, 2015; 31(Supp.2): 38–46. (in Chinese)




Copyright (c)



2023-2026 Copyright IJABE Editing and Publishing Office